COMPOSITION OF REFUSE DERIVED FUELS IN LATVIA AND ESTONIA IN COMPARISION WITH WORLDWIDE AVERAGE VALUES

Dmitrijs Porshnov, Dace Arina, Maris Klavins

Abstract


Information about composition of RDF worldwide was collected using literature analysis. RDF samples produced in Latvia and Estonia were collected, those fractional and elemental composition analyzed using standard methods. Comparing obtained results with worldwide data we have found that the quality of local RDFs in general is higher than typical values, while elevated content of chlorine must be mentioned as a problem. Results also show that majority of chlorine in studied samples exists in organic form. Recommendations to overcome this problem have been developed.

 


Keywords


RDF; SRF; quality; Latvia; Estonia

Full Text:

PDF

References


E. Dace, and D. Blumberga, An assessment of the potential of refuse-derived fuel in Latvia. Manag. Environ. Qual. Int. J. vol. 235), pp. 503-516, 2012. https://doi.org/10.1108/14777831211255088

D. Porshnov, V. Ozols, L. Ansone-Bertina, J. Burlakovs, and M. Klavins, “Thermal decomposition study of major refuse derived fuel components,” Energy Procedia, vol. 147, pp. 48–53, 2018 https://doi.org/10.1016/j.egypro.2018.07.032

R. K. Agrawal, “A Rapid Technique for Characterization and Proximate Analysis of Refuse-Derived Fuels and Its Implications for Thermal Conversion,” Waste Management & Research, vol. 6, no. 1, pp. 271–280, 1988. https://doi.org/10.1177/0734242x8800600143

P. Makkonen,, A. Hotta. ”Experiences of RDF fluidized-bed combustion and gasification, emissions and fuel quality aspects”, presented at Power production from waste and biomass: Advanced concepts and technologies, Espoo, Finland, 2002.

G. Tchobanoglous, H. Theisen, and S. Vigil, Integrated solid waste management: engineering principles and management issues. New York: McGraw-Hill., 2004

Gendebien, A. Leavens, A. Godley, “Refuse derived fuel, current practice and perspectives”. European Commission – Directorate General Environment Final Report B4-3040/2000/306517/MAR/E3, 2003. [Online]. Available: European Commission: http://ec.europa.eu/environment/waste/studies/pdf/rdf.pdf [Accessed April 01, 2019]

[7] Papageorgiou, A. Karagiannidis, J. R. Barton, and E. Kalogirou, “Municipal solid waste management scenarios for Attica and their greenhouse gas emission impact,” Waste Management & Research, vol. 27, no. 9, pp. 928–937, 2009. https://doi.org/10.1177/0734242x09350787

P. S. Calabrò, “The effect of separate collection of municipal solid waste on the lower calorific value of the residual waste,” Waste Management & Research, vol. 28, no. 8, pp. 754–758, 2009. https://doi.org/10.1177/0734242x09351907

C. Montejo, C. Costa, P. Ramos, and M. D. C. Márquez, “Analysis and comparison of municipal solid waste and reject fraction as fuels for incineration plants,” Applied Thermal Engineering, vol. 31, no. 13, pp. 2135–2140, 2011. https://doi.org/10.1016/j.applthermaleng.2011.03.041

A. Gallardo, M. Carlos, M. Bovea, F. J. Colomer, and F. Albarrán, “Analysis of refuse-derived fuel from the municipal solid waste reject fraction and its compliance with quality standards,” Journal of Cleaner Production, vol. 83, pp. 118–125, 2014. https://doi.org/10.1016/j.jclepro.2014.07.085

N. Magasiner, and J. W. de Kock, (1987). Design criteria for fibrous fuel fired boilers. Energy world, vol. 150, pp. 4-12, 1987.

P.K. Herbert, L. Baguss, and J. C. Loeffler, “Low-Btu gas from bark and waste via CFB gasification,” Energy from biomass and wastes, vol 7, pp. 731-751, 1989.

O. Kitani, Biomass handbook. New York, NY: Gordon and Breach Science Publ., 1989.

J. H. Canova and D. J. Bushnell, “Testing and evaluating the combustion characteristics of densified RDF and mixed waste paper,” Energy from Biomass and Wastes, vol. 16, pp. 1191-1191, 1993.

M. L. Murphy, “Integrated Recycling, Resource Recovery, and Energy Facility: The Experience at Louisville, Kentucky”. Energy from Biomass and Wastes, vol. 16, pp. 1257-1257, 1993

T. Abbas, P. Costen, F.C. Lockwood and J.J Ou.: “Co-firing refuse derived fuel (RDF) with fossil fuels in a large-scale laboratory furnace” presented at International Flame Days, Clean combustion of waste and non-conventional fuels, Biarritz, France, 1994.

P. Costen, F. C. Lockwood and J. J. Ou: Analysis of solid waste fuels, APAS Clean Coal Technology, London (UK), Imperial College of Science, Technology and Medicine, EUcontract CT92-0002, 32 p. (1994).

R. Venendaal, Gasification of waste. Evaluation of the Thermoselect and TPS / Greve installations, Energy recovery from waste and biomass. BTG, KEMA en VVAV, Novem-EWAB no. 9407, 114 p. 1994 (in Dutch). Vergassing van afval. Evaluatie van de installaties van Thermoselect en TPS/Greve, Energiewinning uit afval en biomassa, Utrecht, BTG, KEMA en VVAV, Novem-EWAB no. 9407, 114 p. 1994

T. R. Miles, Alkali deposits found in biomass power plants. Golden, CO: National Renewable Energy Laboratory, 1996.

M. Öhman and A. Nordin, “A New Method for Quantification of Fluidized Bed Agglomeration Tendencies: A Sensitivity Analysis,” Energy & Fuels, vol. 12, no. 1, pp. 90–94, 1998, https://doi.org/10.1021/ef970049z

A. Garg, R. Smith, D. Hill, N. Simms, and S. Pollard, “Wastes as Co-Fuels: The Policy Framework for Solid Recovered Fuel (SRF) in Europe, with UK Implications,” Environmental Science & Technology, vol. 41, no. 14, pp. 4868–4874, 2007 https://doi.org/10.1021/es062163e

G. Dunnu, J. Maier, and G. Scheffknecht, “Ash fusibility and compositional data of solid recovered fuels,” Fuel, vol. 89, no. 7, pp. 1534–1540, 2010, https://doi.org/10.1016/j.fuel.2009.09.008

S. Wagland, P. Kilgallon, R. Coveney, A. Garg, R. Smith, P. Longhurst, S. Pollard, and N. Simms, “Comparison of coal/solid recovered fuel (SRF) with coal/refuse derived fuel (RDF) in a fluidised bed reactor,” Waste Management, vol. 31, no. 6, pp. 1176–1183, 2011, https://doi.org/10.1016/j.wasman.2011.01.001

O. N. Kimambo and P. Subramanian, “Energy efficient refuse derived fuel (RDF) from municipal solid waste rejects: a case for Coimbatore,” International Journal of Environment, vol. 3, no. 2, pp. 205–215, 2014, https://doi.org/10.3126/ije.v3i2.10530

J. Kluska, M. Klein, P. Kazimierski, and D. Kardaś, “Pyrolysis of biomass and refuse-derived fuel performance in laboratory scale batch reactor,” Archives of Thermodynamics, vol. 35, no. 1, pp. 141–152, 2014, https://doi.org/10.2478/aoter-2014-0009

Michał Kuna, “Analysis of thermal conversion of non-homogeneous solid recovered fuels,” M.S. thesis, Technical University of Lisboa, Lisboa, Portugal, 2015. . [Online]. Available: Technical University of Lisboa https://fenix.tecnico.ulisboahttps://fenix.tecnico.ulisboa.pt/downloadFile/1126295043833896/Dissertation.pdf.pt/downloadFile/1126295043833896/Dissertation.pdf [Accessed April 01, 2019]

S. Akdağ, A. Atımtay, and F. Sanin, “Comparison of fuel value and combustion characteristics of two different RDF samples,” Waste Management, vol. 47, pp. 217–224, 2016, https://doi.org/10.1016/j.wasman.2015.08.037

H. Haykiri-Acma, G. Kurt, and S. Yaman, “Properties of Biochars Obtained from RDF by Carbonization: Influences of Devolatilization Severity,” Waste and Biomass Valorization, vol. 8, no. 3, pp. 539–547, 2016, https://doi.org/10.1007/s12649-016-9610-5

T. Khosasaeng and R. Suntivarakorn, “Effect of Equivalence Ratio on an Efficiency of Single Throat Downdraft Gasifier Using RDF from Municipal solid waste,” Energy Procedia, vol. 138, pp. 784–788, 2017, https://doi.org/10.1016/j.egypro.2017.10.066

M. Materazzi, “Clean energy from waste: fundamental investigations on ashes and tar behaviours in a two stage fluid bed-plasma process for waste gasification,” PhD dissertation, University College, London. UK 2015.

W. Ma, G. Hoffmann, M. Schirmer, G. Chen, and V. S. Rotter, “Chlorine characterization and thermal behavior in MSW and RDF,” Journal of Hazardous Materials, vol. 178, no. 1-3, pp. 489–498, 2010, https://doi.org/10.1016/j.jhazmat.2010.01.108

W. Bakker, “High temperature corrosion in gasifiers,” Materials Research, vol. 7, no. 1, pp. 53–59, 2004, https://doi.org/10.1590/s1516-14392004000100009

N. Chatziaras, C. S. Psomopoulos, and N. J. Themelis, “Use of waste derived fuels in cement industry: a review,” Management of Environmental Quality: An International Journal, vol. 27, no. 2, pp. 178–193, 2016, https://doi.org/10.1108/MEQ-01-2015-0012

Buekens and K. Cen, “Waste incineration, PVC, and dioxins,” Journal of Material Cycles and Waste Management, vol. 13, no. 3, pp. 190–197, 2011, https://doi.org/10.1007/s10163-011-0018-9

D. Arina and A. Orupe, “Characteristics of mechanically sorted municipal wastes and their suitability for production of refuse derived fuel,” Scientific Journal of Riga Technical University. Environmental and Climate Technologies, vol. 8, no. -1, pp. 18–23, 2012, https://doi.org/10.2478/v10145-012-0003-0

H. Yuan, Y. Wang, N. Kobayashi, D. Zhao, and S. Xing, “Study of Fuel Properties of Torrefied Municipal Solid Waste,” Energy & Fuels, vol. 29, no. 8, pp. 4976–4980, 2015, https://doi.org/10.1021/ef502277u

A. Białowiec, J. Pulka, P. Stępień, P. Manczarski, and J. Gołaszewski, “The RDF/SRF torrefaction: An effect of temperature on characterization of the product – Carbonized Refuse Derived Fuel,” Waste Management, vol. 70, pp. 91–100, 2017, https://doi.org/10.1016/j.wasman.2017.09.020

Z. Xu, S. Zinchik, S. S. Kolapkar, E. Bar-Ziv, T. Hansen, D. Conn, and A. G. Mcdonald, “Properties of Torrefied U.S. Waste Blends,” Frontiers in Energy Research, vol. 6, 2018, https://doi.org/10.3389/fenrg.2018.00065

J. Yu, L. Sun, C. Ma, Y. Qiao, and H. Yao, “Thermal degradation of PVC: A review,” Waste Management, vol. 48, pp. 300–314, 2016, https://doi.org/10.1016/j.wasman.2015.11.041




DOI: http://dx.doi.org/10.17770/etr2019vol1.4128

Refbacks

  • There are currently no refbacks.